擬定維護人員值班表，值班的人要記載運轉的狀況。要常常不守時查看電控清灰設備(包含操控儀、電磁脈沖閥、加熱系統等)運轉是不是正常，有必要時調正清灰的時辰，以確保清灰功率。

　　守時查看緊縮空氣系統是不是正常，氣源壓力能否契合標準央求、安穩。分水濾氣器要常常放水。隨時監視排放出來的煙塵濃度，發現冒灰應及時查看濾袋破損狀況以及過濾室密封的狀況，堵塞漏氣孔或換新袋。單機袋式除塵器在正常的作業時辰有必要確保各料倉每隔30分鐘清一次灰，敞開倉壁振動器，油霧凈化器將合內的鋅粉悉數卸出，以防鋅粉干結及著火。當從鍍小管(4-6分)互換到鍍大管時，由于鍍小管含水量比較小，大管含水量比較大，假定與除塵器內單調的鋅粉接觸簡單構成鋅粉著火，工業除塵器廠家所以在鍍小管轉化鍍大管前有必要將倉內鋅粉卸出，堅持倉內無鋅粉并確保倉內溫度。單機袋式除塵器停機之前，應對除塵濾袋清灰三次，防止濾袋上的鋅粉太多，再用時清灰難度加大。單機袋式除塵器停機后有必要將各倉內鋅粉悉數卸出。

　　一切的設備悉數應該堅持、確保衛生整潔，所加潤滑油有必要要確保質量和數量。跟著大氣環境形勢日趨嚴峻，往常國度環保標準漸趨嚴峻，《車間工業除塵器火電廠 大氣污染物排放標準》單機袋式除塵器比靜電除塵器有更高的除塵功率，排放煙塵濃度能安穩低于50mg/Nm3，致使可達10mg/Nm3以下，簡直終了零排放。在具備以下特征項目中，需求關鍵思索運用布袋除塵技術:很多老電廠制造初期還與市區居民區堅持了必定距離，但跟著我國城市制造的快速翻開，往常現已翻開為靠近居民區，有的致使現已坐落居民布滿寓居區，這類電廠過高的煙塵排放會惹起周圍居民的憂慮，在改造和擴建時應首 選布袋除塵。風光名勝區、環保模范創立城市。環境生態脆弱區。

　　單機袋式除塵器的除塵功率首要受粉塵特性、濾料特性、濾袋上的堆積粉塵負荷、過濾風速等要素的影響。粉塵粒徑直接影響單機袋式除塵器除塵功率。關于1μm以上的塵粒、除塵功率-般都可抵達9.5%。 小于1μm的塵粒中，以0.2-0.4μm塵粒的除塵功率最 低。無論對清潔濾料或積塵濾料都有相似狀況。這是由于對這一粒徑范圍內的塵粒而言 ，幾種捕集粉塵的效應都處于低值區域。塵粒帶著靜電荷也影響除塵功率。運用這一特性，可以預先使粉塵荷電，從而對微細粉塵也能取得很高的除塵功率。濾料的結構類型、表面處置的狀況對單機袋式除塵器的除塵功率有 顯著影響。在普通狀況下，機織布濾料的除塵功率較低，特別當濾料上粉塵層未管樹立或遭到損壞的條件下更是如此;針刺氈濾料有較高的除塵功率;而最 新呈現的各種表面過濾資料則可以取得靠近“零排放”的志向。